FJ519-1982FJ519-1982.pdf 11页

'免费标准下载网(www.freebz.net)中华人民共和国纺织工业部部标准FJ519-82本色棉维混纺纱线本标准适用于鉴定棉和维纶短纤维混用比例各为50肠的本色棉维混纺纱线的品质.1产品品种、规格1.1棉维棍纺纱线的粗细程度，以1000米纱线在公定回潮率时的重量(克)来表示，称为纱线号数，股线公称号数用组成股线的单纱公称号数乘以股数来表示.(t1e.x2)棉维混纺纱线的公定回潮率。以维纶公定回潮率5.0肠和棉公定回潮率8.5呱按干重混纺比例加权平均计算，公定回潮率的小数点计算至二位，修约为一位.计算方法如下:1.35.5X501+008.5X50X’。。肠一6.896棉维混纺纱线的标准重it;1.310。米纱线在公定回潮率时的标准重量(克)=71X0K﹃100米纱线的标准干燥重蛋(克)，_1-105-.681.4单纱和股线的最后成品设计号数必须与其公称号数相等，纺股线用的单纱设计号数，应保证股线的设计号数与其公称号数相等.1.5棉维混纺纱线的号数系列及其10。米的标准重量规定如下。，.5.1棉维混纺纱的号数系列及其10。米的标准重量规定(见表1).1.0301.1001.1241.2001.2171.3111.4041.5001.4981.6001.,5698251_7001.8001.7791.9001.8732.0001.9662_100中华人民共和国纺织工业部1982-12-31发布1983-07-01实施免费标准下载网(www.freebz.net)无需注册即可下载 免费标准下载网(www.freebz.net)F1519-82续表1标准干燥重童公称号数系列重且克/100米.52棉维混纺线的号数系列及其100米的标准重量规定(见表2).表2公称号数系列标准干澡重皿公定回潮串克八00朱6,8%6;1淤最11K22.0602.20012x22.274400一一一一一--.--一13x22.4342.60014x22.62280015x22.80900016x22_99620017x2400600800一—3.7一45一，，-000—::::一—一—.一一一一，气一3.9334.20022x2__4.12040023x24_3074.6004.4944.8004.6825.0008_056695,2A35.6005.43180030x25.6186.00032x25.993一一一.~-一--一一40034x26.3678005()5免费标准下载网(www.freebz.net)无需注册即可下载 免费标准下载网(www.freebz.net)FFJJ519-922技术共求2.1棉维混纺纱的技术指标(见表3)表3品等指标品级指标重，偏差孟t不匀串条干均匀度1克内等曾妙十块板评级比例楠结杂%(优:一:二:三)质粒数别a#9%经纱纬纱不大于不低于不多于上205019502,5优7:3:0:05011^-13185017503,00:7:3:0士2.5280^380(53^45)1040170016003.70:0:7:3上215020502.5优?:3:0:05014^-15195018503,00:7:3:090士2.5280-380(42-V39)110017003,70:0:7:31450上225021502,57:3:0:016^-20竺3,00:，:3:0曲0上2,5280380一，，，.，，卜~~一~~~卜~(36.29)2109500180503,了0:0:7:3140上230021502,6优7:3:0:05021^-30210020003,00:7:3:090上2,5280380(28^-19)1195018503,70:0:7:3140上230021502,石优7:3:0:0603234210020003,00:7:3:0110士2,8280^-380(18^-17)5:13913503.70:0:7:31702.2福维混舫线的技术指标(见表幻表4品等指标公称号效实际拈系数(英制支数)!I等__}{一一显巫担董~还些业巳一}}xf_;%r.!_g*I}级乱‘窄典应毛黔垂俐1一佗%罗一(19厘米)!别I经妙纬纱I不大于I不多于!11x2-20况2三匕265025002.0」鱼一5一二一245023002.5一g5t2.5380480(53/229/2)目三225021003.0_二三10021x2^-30x2习匕_2700__25502.0，远一35380-480二二二250023502.5二二，65t2.5(28/219/2)止三230021503.0三三10032x2-34x2_匕270025502.0优40一二立_25002350_2.5二二.75土2.5380-480(18/2-17/2)二230021503.0二115506免费标准下载网(www.freebz.net)无需注册即可下载 免费标准下载网(www.freebz.net)FJ519-822.3棉维混纺纱线的条千均匀度样照暂按GB398-78《本色棉纱线技术条件》第6条第(7)款规定选用。2.4分等分级2.4.1棉维混纺纱线品等品级的评定以批为单位，规定以同品种一昼夜三班的生产量作为一批，调班日的加班可与其相邻批并批，按GB403-78《本色棉纱线试验方法》进行试验.2.4.2棉维混纺纱线的品等低于二等指标者，作三等;品级低于二级指标者，作三级.2.5棉维混纺纱线品等、品级的评定方法:2.5.1棉维混纺纱线的品等由品质指标、重童不匀率评定，当品质指标和重盘不匀率的品等不同时，按二项中最低的品等评定.2.5.2棉维混纺纱的品级由棉杂粒数、条干均匀度评定，当棉杂粒数和条干均匀度的品级不同时，按两项中最低的品级评定。但条干均匀度的优级批中不允许有二、三级板;一级批中不允许有三级板.棉维混纺线的品级由棉杂粒数一项评定.2.5.3棉维混纺纱线的重A偏差超出允许范围时，作为不合格.在混纺纱线原评等的基础上，顺降一等处理，但降至三等为止.2.6棉维混纺纱线重最偏差月度累计，应按产量进行加权平均(开台致不变，产量稳定，亦可采用算术平均计算)，全月生产在15批以下的品种，应控制在10.50肠及以内.2.7棉维混纺纱线的纤维混坊比例，允许差异范围规定为土2肠，即棉为48-52肠，维纶为52-48肠，生产上应按规定混纺比例控制，维纶混纺比例分析方法按GB2910-82‘二组分纤维混纺产品定量化学分析方法》规定进行.2.8针织用纱，按同号纬纱各项技术标准考核.舀试脸方法3.1棉维混纺纱线的物理指标和外观疵点，均按GB408-78《本色棉妙线试脸方法》进行试验，其温度和回潮率的修正系热见本标准附录。4位脸舰期4.1棉维混纺纱线的交接验收和复验按GB405-78《本色棉纱线脸收规则》的规定进行，生产厂与便用部门双方另有协议者，按协议办理.石标志和包筑5.1棉维混纺纱线的标志和包装，按GB404-78《本色棉纱线包装和标志，的规定进行.5.2棉维混纺纱线的原料代号，规定为c/v,棍纺比例按代号顺序编写，应为50/50,免费标准下载网(www.freebz.net)无需注册即可下载 免费标准下载网(www.freebz.net)FJ519-82附录A栩/维(50/50)续纱强力修正系橄裹(补充件)51,0921,0861,0811,心761,0711.0611.0571.0521.0481,0446…0861,0921,0811,0761,071:一:::1.0611.0571.0521,0481,04471,0921,0811,0761,0711.0661.0621.0571.0531,0481,0448O5﹄1,093了1,0821,0771.0671.0621.0531,0491,0449洲o5口1,0931,0831,078:一:::1.0681.063:一1.0541,0491,04510八73n5口1,0941.0891,0841,078.﹄1.0691.064U1.0551,0501,0461内0﹃UO乃甘甘1,0961,0851,080…1.0701.0651.0601.0561,0511,04712卜”0.o76口山1,0971,0861,0811.0711.0661.0621.0571,0531.0481300n舀n781,099甘1,0881,0831.0731.0681.0591,0541.05014︸UQ.扮n胡1,101:一甘1,090抽︸:一:::1,0851.0751.0701,0611,0561.0521500R‘U时公1,1031,Q921,087.1.0771,0671,0631,0581.054161nO盛85山甘Il1,1061,0951,090.1.080:一:::1,0701,0651,0611.05617In九Jn87J1,109:一1,0981,092…1.璐21,0731,0681,0631.05918，n自0n90山叨1,1121,1011,0961.085:一:;;1,0761,0711,0661.06219‘U941,1151,1101,1041,0991.0891,0841,0791,0.741,0,701.065幼1,1191,1131,1081,1071,0971.0921,0871,0821,0781,0731.06a211.l0，09，工孟1,1231,1181,1121;1071.096…1,0861,0811,0771.072”1.05，的﹄n1,1281,122孟1,1161.1111.1001,0901,0851,0811.076231.0，功n1,1321,1261,1211,1151.105山l1,0901.0801,0951,085舰1.5，10J1,1371,1311,1261,1201.109主…马1,0991,0941,0901.085251.20，1001,1431,1371,1311,1251.115人户1,10_41,0991,0951.090舫1.2511‘1,1481,1421,1361,1311.120互口1.1101,1051,1001.09527l.311垅n1.51,1541,1481,1421,1371.126‘1,1101,1051.101281.37，.12lhl.1211,1611,1551,1491,1431.132孟.1,1161,1111.106幼l.4113抢Jl.1271,1671,1611,1551,1491.138二.1,1221,1171.112301.50‘”Ol.134且1,174L,1681,1621,1561.145…公1,1291,1241.11931l.58，土14点0l.141,1821,1761,1691,1631.1521,1361,1311.126脍115‘l.1481,1901,1841,1771,1711,1651,160二咭1,1431,1381.133洲，16八l.1561,1981,1921,1851,1791,1731,1671…乙1,1511,1461.140润‘.17人U1,2071,2001,1941,1821,176之1,1591,1541.148:45117O1,2161,2101,203:一:::1,1911,184通J:::::1,1671,1621.157ii卜免费标准下载网(www.freebz.net)无需注册即可下载 免费标准下载网(www.freebz.net)F1519-82续表回潮率W4.64.74.84.9{5.05.15.25.35.45.55.6温度飞、、一一一—万—，.一.一~，--------二----一-升~一-一一.一5031.0391.0351.0311,0281,0241,0201,0161.0131.0101,0066031.0391.0351.0311,0281,0241.0171.0131.0101.0067031.0401.0361.0321,0281,024:一:::1,0妞1.0131.0101,0078041.0401.0321,0281,0241,0211.0171.0141.0101,0079:一:::041.0411.0331,0291,0251,0211,0181.0141.0111,00810051.0421.0341,0301,0261,0221,0191.0151.0121,008Jl1.043:::1.0351,0311,0271,0231,0201.0161,0131,00908l21.0441.0361,0321,0281,0251,0211.0181,0141.01113:一:::1.0461.0381,0341,0301,0261,0231.0191,0161,012一:::141.0481.0431.0391一351",0321,0281,0241.0211,0171,0141.011151,.0501.0461.0421,0381,0341,0301,0261.0231,0191,0161,013161.0521.0481.0441,0401,0361,0321,0291.0251,0221,0181,015竹1.0551.0511.0461,0421,0391,0351,0311.0281,0241,0211,017181.0581.0531.0491,心451,0411,0881,0341.0301,0271,0231,020191.0611.0561.0521,0481,0441,0411,0371.0331,0301,0261,023201.0641.0601.0561,0521,0481,0441,0401.0361,0291,026211.0681.0641.0591,0551,0511,0盯1,04"41.040:一:::1,0331.02921.0721.0671.0631,0591,0551,0511,047L.04心1.0401,0371.033231.0761.0721.0671,0631,0591,0551.0511.0481.0441,0411.037241.0801.0761.0721,0681,0641,0601.0561.0521.0481,0451.041251.0851.佣11.0771,0721,0681,0641.0601.0561.0531,0491.046261.0901.0861.0811,0771,0731,0691.0651.0611.0581,0541.051271,.0961.0911.0871,0831,0781,0741.0701.0661.0631,0591.056281.1公21.0971.0931;0881,0841,0801.0761.0721.0681,0641.061291.1081.1031.0981,0941,0901.0861.0821.0781.0741,0701.067肋1.1141.1091.1051,1001.0961.0921.0881.0841.0801,0761.072311.1211.1161.1111,1071,1031.0981.0941.0901.0861,0821.079321.1281.1231.1181,1141,1091.1051.1011.0971.0931.0891.0853八0肉1.1351.130L.1261,1211,1171.1121.1081.104”甘匕1.1001.092“1.143，nn1.1381.1341,1291,1241.1l.ls1201.1161.1111.107二一舀1.10035，1‘1.1521.1471,1421,1371.1321.1231.1191.115止孟11.107;n9免费标准下载网(www.freebz.net)无需注册即可下载 免费标准下载网(www.freebz.net)FJ519-82!6.56.66.7一9730.9780,9769730.9780,9769730,9780,9769740,9790.9769750.9790.9770.9800,9780.9750娜0.9吕10.97909780.9820.9800咖0,9840.98109800.9850.9839820,日合70.9850.9890.9870.9850.9920.9890.9870.9940.9920.9890,9970.9940.9921.0000.9980.9951.0031.0010.9981.0071.0041.0021.0101.0081.0051.0141.0121.0091.0191.0161.0131.0231.0201.0181.0281.0251.0231.0331.0301.0281.0361.0351.0331.0441.0411.0391.0501.0461.0441.0561.0531.0511.0631.0601.0571.0701.幼671.0641.0771.0741.071510免费标准下载网(www.freebz.net)无需注册即可下载 免费标准下载网(www.freebz.net)FJ519-82续表6.86.97.07.17.27.37.47一57.67.77.8温度野50.9710.9670.9650.9630,9590.9580.9560.9540.95360.971:一:::!0.9670.9650.963:一:::0,9590.9580.9560.9540.95370.971公.9690.9670.9650.9630,9610,9590.9580.9560.9540.953污0.9720.9700.9680.9650.9640,9620,9600.9580.9570.9550.95390.9720.9700.9680.9660,9620,9600.9590.9570.956100.9730.9710.9690.967:一:::0.9630.9610.9600.9580.956:一:::10.9740.9720.9700.968口.9640.9620.9610.9590.9570.956120.9750.9730.9710.969:一::)0,9650,9630.962介.9600.9580.95713D.9770.9750.9730.9700,9690,9660,9650.9630.9610.95814D.9780.9760.9740.9720,9700,9680,9660_9660.963:一:::0.960巧0.9800.9780.9760.9740.9720,9700.9680,9660.9650.9630.961160.9820.9800.9780.9760.9740,9720.9700.9680.9670,9650.963170.9840.9820.9800.9780,9760.9740.9720_9710.9690.9670,965180.9870.9850.9830.9810,9790.9770.9750.9730.9710.9700,968190.9900.9880.9850.9830,9810.9790.9780.9760.9740.9720,971200.9930.9910.9880.9860.9840,9820.9810,9790.9770.9750.973210,9960.9940.9920.9890,9870,9850.9840,9820.9800.9780.976韶0.9990.9970.9950.9930,9910,9890.9870,9850.9830.9820.980邢n0811.0031.0010.9990.9960.9940.9920.9910.9890.985”.甘七0.987别1.005肉甘甘吕呼了1.0071.0021.0000,9匀日0.9960.9940.9壮0.9910.989…256O0，1.0111.0091,0061.0021.0000.9980.997“U.孟0.9950.9932e自O951.0151,0131.口11:一::;1,0071,0051.0031.0010.9990.997UU271.0201,0181.0161.0131.0111,0091.0071.0051.0031.0021.的0281.0251,0231,0211,0181,0161,0141.0121.0101.0081.0071.005湘1.0301,0281,0261.0231,0211,0181.01了1.0151.0131.0121.010300201,0361,0341,031…甘1,0271,0241.0231.0211.0191.0151.017内书八品﹄J‘U山翻1.0411,0391,0371,0331,0301.0291.0261.0241.0231.0213，n‘，创1,045U马二1,04公1,0431,0391,0361.0351.0321.0301.0291.027n几舀d1,0541,0521,0500471,0451,0421.0411.0391.0361.0351.033”JJ，1,0611,0591,0561,0521,0491.0471.0451.0431.039，rdJ1.0681.0661.063:一:::1.0591.0561.0541.0521.050:一::;1.046、11免费标准下载网(www.freebz.net)无需注册即可下载 免费标准下载网(www.freebz.net)FFJ1619-82续表50.9520.9500.9490.9480.9460.9450.9440.9420.9410.94160.9520.9500.9490.9480.9460.9450.9440.9420.9410.94170.9520.9500.9490.9480.9460.9450.9440.9420.9410.94150.9520.9510.9490.9480.9470.9460.9460.9420.9420.94190.9530.9510.9500.9490.9470.9460.9450.9430.9420.942100.9530.9520.9510.9490.9480.9470.9460..9440.9430.94210.9540.9580.952心.9500.9490.9480.9470.9450.9440.943120.9550.9540.9530.9510.9500.9490.9480.9460.9450.944130.9570.9550.9540.9540.9510.9500.9490.9470.9460.946140.9580.9570.9560.9540.9530.9520.9510.9490.9480.947150.9600.9590.9570.9560.9550.9540.9530.9510.9500.949场0.9620.9610.9590.9580.9570.9560.9550.9530.9520.951170.9630.9610.9600.9590.9580.9570.9650.9540.95318:::::0.8650.9640.9630.9610.9600.9590.9570.9560.955190.9680.9660.9650.9640.9630.9620.9600.9590.958幼:一:::0.9710.9690.9680.9660.9650.620.9610.961幻0.9750.9740.9720.971:一::;0.9690.9680.9650.9640.964韶0.9780.9770.9760.9740.9730.9720.9710.9690.9680.967230.9820.9810.9790.9790.9760.9750.9740.9720.9710.970洲0.9860.9840.9830.9820.9800.9790.9780.9760.9750.974巧0.9900.9990.9870.9860.98d0.马启30.9920.9800.9790.978邓0.9940.9930.9910.9900.9880.9870.9860.9840.9830.982270.9980.9970.9960.9940.9930.9920.9910.980.9870.987281.0031.0021.0000.9990.9970.9960.9950.9930.9920.991肠1.0081.0071.0051.0041.0021.0000.9980.9970.99301.0131.0121.0111.0091.008:::::1.0051.0031.0021.001盯1.0191.0181.0161.0151.0131.0121.0111.0091.0081.007321.0251.0241.0231.0211.0191.0171.0141.0131.01231.0311.0301.0281.0271.025:::;:1.0231.0201.0191.018341.0371.0361.0351.0331.0311.血91:0271.0261.025351.0451.0431.0411.0401.038:一::)1.0361.0331.0321.031几卫2免费标准下载网(www.freebz.net)无需注册即可下载 免费标准下载网(www.freebz.net)F1819-82续表IJ}，二}。.。}，.，}9.3}9.3}，.‘}，.。}。.。}。川，.。一，.。10.0温哑度t~、、、{!}}}!}!}}}{50.940卫0.9390.9390.9380.9380.9370.9370.9360.9360.9360.936一60.9400.9390.9390.9380.9380.9370.9370.9360.9360.9360.93670.9400.9390.9390.9380.9380.9370.9370.9370.9360.9360.93680.9400.9390.9390.9380.9380.9380.9370.9370.9360.9360.9369.0.941.0.9400.9400.9390.9390.9380.9380.9370.9370.9370.9371010.942卫0.9400.9400.9390.9390.9380.9380.9380.9380.938n.!0.943l:一::;0.9410.9410.94"00.9400.9390.9390.9390.9380.938琦we0.9440.9430.9420.9420.9410.9410.9400.9400.9400.9400.94013l0.9410.9450.9440.9440.9430.9430.9420.9420.9410.9410.941140.9420.9470.9460.9450.9440.9430.9440.9430.9430.9430.942巧蝴l0.0.940.94"80.9470.9460.9460.9450.9450.9450.9440.944拓0.9500.9460.9500.9490.9480.9480.9470.9470.9470.9460.946952一170.0.9520.9510.9500.9500.9490.9490.9490.9480.9480.9481895es0.e0.9540.9530.9530.9520.9520.951&.9510.9510.9500.95019we0.957e0.9560.9560.9550.9550.9540.9540.9540.9530.9580.953200.960es0.9590.9590.9580.9580.9570.9570.9570.9560.9560.956210.9630.9620.9620.9610.9610.9600h"I00.9600.9590.9590.95920.966es0.9650.9650.9640.9640.9630.9630.9620.9620.9620.96223wt0.9700.9690.9680.9670.9670.9670.9660.9660.9660.9650.965240.973心0.9730.9720.9710.9710.9700.口70一0.9700.9700.9690.969250.9770.9770.976仇9750.9750.9740.97401.97各0.9730.9730.973肠l0.9810.9810.9800.9790.9790.9780.9780.9770.977l0.9770.97727e0.986l0.9850.9840.9830.9890.9830.9820.9810.9810.9810.981朋.一0.9900.9900.9890.9880.9880.9870.9870.9860.9860.9860.986290.995110.9950.9940.9390.9930.9920.9920.9910.9910.9910.99130.l1.000es1.0000.9990.9980.9980.9970.9970.9960.9960.9960.99631es1.006es1.0051.0041.0031.0031.0081.0021.0021.0011.0011.00132es1.0121.0111.0101.0帕1.0091.0081.0081.0071.0071.0071.0073es1.016es1.0171.0151.0141.0141.0131.0131.0131.01334es1.0241.0231.:;:1.021251.0211.0201:0201.01935l1.0311.0301.0291.028:::::1.0271.0271.0261.026:一::::一:;:.免费标准下载网(www.freebz.net)无需注册即可下载 免费标准下载网(www.freebz.net)FJ519-82附加说明:本标准由纺织工业部科技司提出，由上海市纺织工业局计量标准管理所、上海市棉纺织工业公司归口。本标准由北京市纺织工业局起草.本标准主要起草人阎秀梅、汪世爱等。免费标准下载网(www.freebz.net)无需注册即可下载'